HH-528CX has excellent dyeing levelness and slow, can control the initial dyeing rate of dyeing to play excellent dyeing results. HH-528CX has excellent high-temperature dispersion stability, thus effectively reduce the adhesion phenomenon oligomers to ensure that no dye in the dyeing process of cohesion, HH-528CX with low foam nature, to prevent the fabric during operation due to multi-bubble caused by floating knotted dyeing defects caused by dyeing flowers. HH-528CX leveling strong consumer color is small, that have been generated color flowers, stain for Correction, while the shade has remained basically unchanged obtain good dyeing reproducibility, while HH-528CX has a strong high-temperature stability and permeability, Which can be described as ultra-fine fiber dyeing best partner.

HH-528CX具有優異的勻染及緩染性，能控制染色初期的上染率，發揮優秀的勻染效果。HH-528CX具有極佳的高溫分散穩定性，從而有效降低低聚物粘附的現象發生，確保染色過程中無染料凝聚，HH-528CX具有低泡性，能防止織物在運行過程中因多泡而引起漂浮打結造成的染疵、染花等。HH-528CX勻染性強而消色性小，對已產生的色花、色斑進行回修，而色光基本不變，可得到很好的染色再現性，同時HH-528CX具有很強的高溫穩定性和滲透性，因而可稱為超細纖維染色最佳伴侶。

 

【Physical and Chemical Properties】

Properties: light yellow to yellow transparent liquid

PH value: 6.5-7.0 (1% aqueous solution)

Active ingredient: 100%

Solubility: easily soluble in water

Ionic nature: Non-ionic

【物化性能】

性 狀： 淡黃色至 黃色透明液體

PH值： 6.5-7.0（1%水溶液）
有效成分：100%
溶解性： 較易溶于水
離子性：非離子 

 

【Scope and Characteristics】

This product is applicable to high temperature and pressure in the ultra-fine polyester fabric dyeing, and does not contain any chemical solvents, which do not produce pollution of the environment is the upgrading of the environment-friendly green additives.

1) The content of the sample is 100% effective

2) is mainly used superfine polyester fiber leveling agent. Dyeing and transfer dyeing, dyeing and slow is better than average high temperature leveling agent.

3) completely environmentally friendly, low-foam.

4) Use if you want to dilute the solution for clear and transparent liquid, you need to add this product based on the solvent can be 10-15%.

5) suggested that the ratio of open-dilute the use of an opening 6-8 times.

【適用范圍及特點】

本品適用于超細滌綸織物高溫高壓染色，且不含任何化學溶劑，從而對環境不產生污染，是升級換代的環保型綠色助劑。

1）該樣品有效含量為100%

2）主要用作超細旦滌綸纖維勻染劑。勻染性和移染性、緩染性要好于普通的高溫勻染劑。

3）完全環保，低泡。

4）使用如果想稀釋液為澄清透明液體，需要在本品基礎上加10-15%溶劑即可。

5）建議開稀比例為1開6-8倍使用。

 

【Usage】

Carried out according to conventional process, the following process is for reference only, please adjust the sample as appropriate, to select the best technology curve and the dosage.

Dosage: Dyeing general dosage is 0.3-0.5 g / l, while flower color can be used as repair time, the dosage is generally 1.0-2.0g / l (I recommend the use of plant disperse Putty to repair the effects of the purpose of more specific)

Bath ratio: 1:10

Dyeing temperature :125-130 ℃

Holding time :30-60min

【使用方法】

按常規工藝進行，以下工藝僅供參考，敬請?jiān)嚇幼们檎{(diào)整，選擇最佳工藝曲線和用量。
用 量：染色時一般用量為 0.3-0.5 g/l ，同時可以作為修補色花時用，用量一般為1.0-2.0g/l（建議使用我廠分散染料修補劑，修補效果目的更為明確）
浴 比：1∶10
染色溫度：125-130℃
保溫時間：30-60min

 

【Packaging and Storage】

50,120 kilograms of plastic barrels, sealed and stored at room temperature storage period of 6 months.

【包裝與貯存】

50、120公斤塑料桶，密封貯存，常溫下貯存期6個月。